Hello Warrenh, I'm headed to the factory next week for my one year warranty work and on the long list of items below is the bedroom slide leak, did you request the double seal or was it the last effort for them. Also I mentioned in previous post I was going to freightliner first and they had to change my appointment so I will have the factory take care of the overheating/fan problem. Also just curious how this list compares to others. I have also found that a tube of clear liquid nails took about seven small items off this list, somewhat dissapointing about all the problems but I still love the coach.
Ben Lucchese – 2005 40kd Horizon #818-681-5269 Service date 10/17/05
Work order Conf. # 44039 Seiral # 70f43059 Attn: Chuck 1-641-585-6967
Problems to be addressed:
1) Dishwasher rear cabinet mount broken – unit tips forward when pulled out.
2) Washer and dryer support shelf broken – proped up with board now needs extra heavy support to carry heavy load of unit when in use.
3) Engine battery drains after a week
4) Keyless entry never has worked, originally was replaced at the factory upon pick up and worked for only 1 day.
5) Kitchen wall GFI dead
6) Shower valve- rust running down wall
7) Living room slide awning fabric - corner loose
Lumbar support handel on passenger chair broken
9) Water comp.– checked fuses and still Water hose real & Level monitor dead
10) Rechargable flashlight does not work
11) Toilet paper holder broken – bolt stripped
12) Electric cord reel always hangs up for the last 5 feet
13) Awning wind sensor does not work when switched on
14) Hyd. Jacks very slow coming up (10-15 minutes sometimes)
15) Bathroom hall wall very loose by the floor and interior floor moulding loose
16) Bedroom slide leaks in heavy rain.
17) Bedroom vanity sink stopper broken and wall socket loose
1
Front DVD player won't play DVD
19) Hallway door by kitchen gets stuck when trying to open, bad scrape along bottom.
20) Air Horn dead but blows when setting the cruise control
21) Cabinet to the right of dishwasher by oven – stain very blochey
22) Align exterior cabinet doors, latches hard to open.
23) Drivers seat motor slow and whining when moving back
24) Rest easy couch motors very slow and needs assist to bring up
25) Kitchen slide couch window latch dose not line up
26) Two broken drawer latches
27) One 2 way radio won't charge
2
GE speedcook oven dead – power to plug but unit dead
29) Loud rattle/banging around entry step when driving
30) External tv coax cable connection loose into back – bad picture
31) Engine overheats (210-220) under minor uphill load have to down shift to third to stay under temp. Fluid level is fine.
32) Dash plastic coating peeling over Radio area
33) Front roof cap has large cracks in the bonding
34) Passenger side leather sofa bed, lower portion of couch used to pull out to recline into bed is loose or broken.
35) Big Gust of wind caught the front door and opened to far now closes hard.
36) Light behind electric water heater switch is out
37) Metal band molding on top front step is loose
Requested service:
1) One year recommended check up
2) Any avaliable upgrades, improvments or recall issuses.
3) 1st. schedualed Lube and oil for chassis
4) Gen set service and lube.
Why,if you have such a distaste,do you bother to read the Winnie forums? 
